djderek1971 wrote:Hi folks.I have 2008 2.2 TDci transit. Please help, I am self employed and rely on my van. I only got this ford a few months ago after ditching my renault traffic which caused me thousands in repairs, including Map sensor, MAF sensor, EGR, clutch etc.
Hi there thanksOk the most common cause of this concern on the custom is a faulty DPF sensor (Diesel Particulate Filter) The DPF sensor should read around 0.5 volts with ignition on What we see is it reads too high around 1.4 volts and makes the pcm (Powertrain Control Module) think the DPF is completely blocked As it can only assume this from the voltage it sees from the dpf sensorThe dpf
Preventative cleaning starts from as little as £89.99 (for a car) If your vehicle has an EGR issue, or has even failed an EGR manual clean by a garage, and therefore requires further assistance to resolve the problem there is no better alternative than a skilled UKCC technician providing our 3 or 4-stage carbon cleaning service.

Welcome to Piggypower a guide to removing the turbocharger on a Ford Transit Custom 2.2tdci!Any questions, please feel free to use the comments.If you thi

Investigating & fixing a Ford Transit Custom 2015 Model 2.2 with poor starting , Not idling & cutting out, not revving at times & no throttle response. Engin So did you do both egr blank and clean out. Yes I didalthough you cannot completely blank off a Mk7 EGR, it will throw up fault codes, I have fitted a blanking plate with an 8mm hole in the middle so the MAP sensor doesn't go crazy. The MAP sensor expects to see a certain manifold pressure at any given rpm/load/throttle position, if it doesn
Ford Transit Custom 2.2tdci 2013 no start. I have a transit custom in and we found that a mouse had chewed a wire to the pcm causing no diag with the van at all. I fix the wire and now have diag, but the van still will not start. I have chased the fault to the fuel pressure solenoid - fuel is getting to the high pressure pump, but not to the rail.
En moyenne le prix du changement de vanne EGR est de 286 € sur une Ford Transit Custom. Toutefois, le prix du changement de vanne EGR sur une Ford Transit Custom peut être très variable d'une version du modèle à l'autre. Nous vous conseillons donc de vérifier sur Vroomly quel est le meilleur prix pour un changement de vanne EGR en
EGR Valve. I have a 2007 Ford Transit, having done only 80,000 miles. The Engine Management Light is permanently on. The main dealer has reset it and tells me the EGR valve wants replacing again. It remained off for approx 2 weeks and then lit up again. This is the 5th time it has needed replacing. The contact owns a 2006 Ford F-250 sd. The contact stated that while traveling approximately 5 mph, smoke emitted from the exhaust pipe. The vehicle was moved to the shoulder where it was shut off and towed to the dealer. The technicians determined that the egr valve, egr cooler and oil cooler had failed. FORD TRANSIT CUSTOM 2012-2015 2.2 TDCI EGR COOLER (Fits: Ford Transit Custom 2013) £22.00. Free postage. 2013 MK7 RWD Ford Transit 2.2 TDCI Euro 5. EGR Pipe BK2Q9E470CA 118K. £29.99. Click & Collect. Free postage. .
  • tqx8cx94l2.pages.dev/58
  • tqx8cx94l2.pages.dev/367
  • tqx8cx94l2.pages.dev/301
  • tqx8cx94l2.pages.dev/86
  • tqx8cx94l2.pages.dev/492
  • tqx8cx94l2.pages.dev/60
  • tqx8cx94l2.pages.dev/224
  • tqx8cx94l2.pages.dev/150

    • ford transit custom egr valve problems